Product ID:AEROSHELL OIL W 120 (SAE 60),60067
MSDS Date:02/22/1995
FSC:9150
NIIN:00-753-4937
MSDS Number: CBSBP

SHELL OIL COMPANY

HEALTH, SAFETY AND ENVIRONMENT
HOUSTON, TX 77210
US

Emergency Phone: 713-473-9461/800-424-9300(CHEMTREC)

Info Phone: 713-241-4819/4141/2252 FAX -6511

Cage: 54527

SHELL OIL COMPANY

674414 HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

MINERAL OIL,PETROLEUM DISTILLATES,HYDROTREATED(MILD),HEAVY

CAS: 64742-54-7

RTECS: PY8035500

Fraction By Weight: 40 - 50%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

SOLVENT REFINED HYDROTREATED RESIDUAL OIL

CAS: 64742-57-0

Fraction By Weight: 50 - 60%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

ADDITIVES

Fraction By Weight: <= 5%

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY
TRACT. ACUTE- MAY CAUSE SLIGHT EYE IRRITATION. MAY CAUSE MILD SKIN
IRRITATION. REPEATED/PROLONGED SKIN CONTACT MAY CAUSE DERMATITIS.
INHALATION OF VAPORS/OIL MIST MAY CAUSE IRRITATION OF UPPER
RESPIRATORY TRACT. SLIGHTLY TOXIC IF INGESTED. CHRONIC- MAY CAUSE
DERMATITIS.
Explanation of Carcinogenicity:NONE.
Effects of Overexposure:IRRITATION, REDNESS, DERMATITIS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES. HOLD EYELIDS OPEN. SKIN:WIPE OFF EXCESS & WASH SKIN WITH
SOAP & W ATER. ORAL:DO NOT INDUCE VOMITING. SEEKMEDICAL ATTENTION.
IF SPONTANEOUS VOMITING OCCURS, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION OF VOMITUS INTO LUNGS.

Flash Point Method:PMCC
Flash Point:487F,253C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.

Spill Release Procedures:SPILLS CAN BE TAKEN UP ON SAND, CLAY, EARTH &
SHOVELD INTO CONTAINERS FOR DISPOSAL. PREVENT RUN-OFF TO ENTER
WATERWAYS, SEWERS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE AWAY FROM OXIDIZERS. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:MINIMIZE SKIN CONTACT. WASH THOROUGHLY AFTER
HANDLING. AVOID EYE CONTACT. DO NOT BREATHE MISTS.

Respiratory Protection:NONE NORMALLY REQUIRED. IF VAPOR OR MIST IS
GENERATED, WEAR NIOSH-APPROVED RESPIRATORY PROTECTION. SUPPLIED AIR
RESPIRATORY PROTECTION SHOULD BE USED FOR CLEANING LARGE SPILLS OR
FOR ENTRY INTO TANKS, VESSELS OR OTHER CONFINED SPACES.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Protective Gloves:NITRILE RECOMMENDED
Eye Protection:CHEMICAL GOGGLES/FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA/% CHANGED. NOTE TO PHYSICIAN:IF >2 ML/KG HAS BEEN INGESTED AND
VOMITING HAS NOT OCCURED, EMESIS SHOULD BE INDUCED WITH
SUPERVISION. KEEP VICTIM'S HEAD BELOW HIPS. IF SYMPTOMS SUCH AS
LOSS OF G AG REFLEX, CONVULSION/UNCONSCIOUSNESS OCCUR, GASTRIC
LAVAGE USING A CUFFED ENDOTRACHEAL TUBE SHOULD BE CONSIDERED.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:-4F,-20C
Spec Gravity:0.8984
Viscosity:24-26CS @212F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:ORANGE TO RED OIL - SLIGHT HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, FLAMES
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
COMPD. MAY FORM.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.